Golf cart LIFEO4 Battery 48V 100Ah E-Z-Go
LiFePO4 3.2V 100Ah cell
Standard Charge Current
Max. Charge Current
Battery management System (BMS)
Continuous Discharge Current
Peak Discharge Current
Full Charged Voltage
58.4V(3.65V per cell)
Charge Cut-off Voltage
62.4V (3.9V per cell)
Discharge Cut-off Voltage
89.7V (2.0V per cell)
Charging: 0°C ~ 45°C
Discharging: -20°C ~ 55°C
(Recommended to store 20 ± 5°C for long term storage)
2000 times (80% of initial capacity at 0.2C rate, IEC Standard)
1. Solar system, energy storage system, UPS etc.
2. Golf carts, electric vehicles, motorcycle, automobile starter battery, trolley, electric boat etc.
3. Sealed Lead-Acid battery replacement.
4. Forklift, srubbing machine, motive power bank etc.
5. Others: power tools
(10)Modular and quick plug design makes it easy to use and maintenance
Battery can be controlled with remote monitoring via communication interface.
ASIC chip, high precision acquisition, automotive grade material, Lightning Surge Immunity Test, redundancy design, high temperature aging, electron- static discharge, EMC, current balancing technology, maintenance-free battery system, The water detection, smoke detection, collision warning system actively.
Temp. Balance & Bonding
Aluminum wire bonding process with bus-bar design, triaxial vibration design, waterproof and dustproof design, structure lightweight design technology, which solved the core issue of power battery, improving the safety, reliability and stability. At the same time, the problem of BATTERY heating, heat dissipation was managed by temperature equalization technology ,which improve the battery performance and life span. PLB continue to optimize the battery pack design, so as to ensure the safety of product.
Our battery is with 3000 - 5000 cycles. On average, good quality lead acid batteries last between 100 - 300 cycles in a golf cart. After 150 cycles the lead acid batteries can produce less than half of their rated capacity meaning you get less than half of the range you got when they were new. In the long run, you would need to replace lead acid up to 10 times to get the same cycle life as 1 set of our battery
Lighter Weight/Higher Energy Density
Our battery weigh is about 70% lighter than lead batteries. A typically 48V golf cart will have around 500-600 lbs. of lead acid batteries. Switching to lithium will remove over 300 lbs. out of the cart. This will reduce the amount of energy required to get your cart up to speed and will help reduce wear and tear on your carts controller, motor, suspension, frame and tires.
Our battery hold a higher voltage during use than lead batteries. This equals more torque for your motor and allows the controller and electronics to run at their optimal efficiency. When you step on the pedal with lead batteries, the voltage can drop below 10V causing the controller to run inefficiently and providing less power to the motor which reduces torque. The higher voltage of our golf cart batteries will allow your cart to get up to speed quicker, and hold the speed higher, throughout the entire charge cycle and while going up hills.
OUR batteries are 99.1% efficient whereas lead acid batteries can be as little as 50 - 80% efficient. When you charge lead acid batteries, you can lose anywhere from 10% - 50% of the energy from the charger to your batteries. This means 50% of the power used to charge your golf cart is being lost due to resistance from the lead batteries. Using your existing charger, lithium batteries can charge up to 50% faster. We recommends you purchase one of our chargers for your golf cart to get the best performance and longest life from our lithium golf cart batteries. OUR lithium batteries may be recharged in less than 1 hour when you purchase a high-speed lithium charger from us.
Our lithium golf cart batteries are designed to allow you to safely use 100% of the rated capacity without lowering the life expectancy. Lead acid batteries are only recommended to be drained 50%. Imagine filling up your gas tank with 100 gallons of gas and the car only being able to use 50 gallons before needing to refuel.
With professional mechanical design, with special bracket inside there is not any moving at all.
to lay the battery block, and the each little space of the cells will be easy for the air mesh,
、We custom 48V 100Ah,200Ah,300ah,400ah,500ah,600ah……battery for all kind of applications.